Tesla Model X Service Manual Repair Procedures

Introduction
- How To Use This Manual
- Repairs and Replacements
- Warranty Service Regions
- Abbreviations and Symbols
Best Practice
- Electrical Precautions
- General Precautions
- Environmental Precautions
- General Fitting Instructions
- Oil Seals
- Locking Devices
- Flexible Pipes and Hoses
- Wheels and Tires
- Air Bag and Supplementary Restraint System (SRS) Precautions
- SRS Component Replacement Policy
- Air Conditioning System Precautions
Charging
- General
- Charging Precautions
Technical Data
- Motor
- Steering
- Suspension
- Wheel Alignment
- Brakes
- Wheels
- Tire Pressures
- Electrical
- Fuse Locations
- Exterior Dimensions
- Weights
Identification Numbers
- Vehicle Identification Number
- Drive Unit Numbers
- Manufacturing Certification Label
- Vehicle Paint Codes
- Serial Number
Tesla Special Tools
- Reason for Special Tools
- Badge and Spoiler Tools
- Battery Cooling System Tools
- Bosch Supplied Tools
- Electronic Devices
- Hardware
- Large Tools
- Safety
- Templates
- Wire Harnesses
- Small Hand Tools
Lifting and Jacking
- Raising and Supporting the Vehicle
Fluids and Capacities
- Fluids
- Fluid Capacities
00 INSPECTION AND SERVICE
- Annual Service
10 BODY
- Jack Mode Activation
- Raise Vehicle - 2 Post Lift
- Raise Vehicle - 4 Post Lift
- Fascia Assembly - Front (Remove and Install)
- Fascia Assembly - Front (Remove and Replace)
- Bumper Assembly - Front (Remove and Replace)
- Bright Trim - Upper Grille (Remove and Replace)
- Valance - Front Fascia (Remove and Replace)
- Skid Plate Chin Spoiler (Remove and Replace)
- Fascia Assembly - Rear (Remove and Install)
- Fascia Assembly - Rear (Remove and Replace)
- Bumper Assembly - Rear (Remove and Replace)
- Grille - Front Upper (Remove and Replace)
- Surround - Grille - Front Upper (Remove and Replace)
- Carrier - Grille - Front Upper (Remove and Replace)
- Panel - Closing - Upper - Front Fascia (Remove and Replace)
- Panel - Closing - Lower - Front Fascia (Remove and Replace)
- Grille - Front Lower (Remove and Replace)
- Fascia Bracket - Center (Remove and Replace)
- Spear - Fog Light - Upper - LH (Remove and Replace)
- Spear - Fog Light - Lower - LH (Remove and Replace)
- Retainer - Sill - Front - LH (Remove and Replace)
- Retainer - Sill - Rear - LH (Remove and Replace)
- Windshield Assembly (Remove and Replace)
- Sensor - Light/Rain (Remove and Replace)
- Liftgate Glass (Remove and Replace)
- Glass - Rear Quarter Window - LH
- Applique - Spine - Center (Remove and Replace)
- Closing Plate - Spine (Remove and Replace)
11 CLOSURES
- Hood Assembly (Remove and Install)
- Liftgate Assembly (Remove and Install)
- Liftgate Drain - LH (Remove and Replace)
- Door Assembly - Front - LH (Remove and Install)
- Door Assembly - Front - LH (Remove and Replace)
- Door Assembly - Rear Upper - LH (Remove and Install)
- Door Assembly - Rear Lower - LH (Remove and Install)
- Front Door Drive Unit - LH (Remove and Replace)
- Lower Spring (Remove and Replace).xml
- Pop Actuator - Front Door - LH (Remove and Replace)
- Rear Door Spring - Front - LH (Remove and Replace)
- Rear Door Hinge - Primary - Front - LH (Remove and Replace)
- Rear Door Hinge - Secondary - Front - LH (Remove and Replace)
- Module - Rear Door Electromechanical Controller - LH (Remove and Replace)
- Module - Rear Door Electromechanical Controller - RH (Remove and Replace)
- Module - Ultrasonic Door Sensors - LH (Remove and Replace)
- Module - Front Door Controller - LH (Remove and Replace)
- Module - Rear Door Controller- LH (Remove and Replace)
- Sensor - Ultrasonic - Rear Door - LH (Remove and Replace)
- Carrier - Sensor - Ultrasonic - Rear Door - LH (Remove and Replace)
- Gas Strut - Hood - LH (Remove and Replace)
- Strut - Rear Door - Primary - Forward - LH (Remove and Replace)
- Strut - Rear Door - Secondary - Forward - LH (Remove and Replace)
- Power Strut - Liftgate - LH (Remove and Replace)
- Hinge - Hood - LH (Remove and Replace)
- Switch - Rear Door - Door Mounted - LH (Remove and Replace)
- Switch - Rear Door - B-pillar - LH (Remove and Replace)
- Pinch Sensor (1st row) - LH (Remove and Replace)
- Pinch Sensor (2nd row) - Front - LH (Remove and Replace)
- Pinch Sensor (2nd row) - Rear - LH (Remove and Replace)
- Latch - Door - Front - LH (Remove and Replace)
- Latch and Cinch Motor - Door - Rear - LH (Remove and Replace)
- Striker - Door - Front - LH (Remove and Replace)
- Striker - Door - Rear - LH (Remove and Replace)
- Striker - Hood (Remove and Replace)
- Latch - Hood (Remove and Replace)
- Actuator - Latch - Hood (Remove and Replace)
- Latch - Liftgate (Remove and Replace)
- Striker - Liftgate (Remove and Replace)
- Actuator and Cable - Cinching (Remove and Replace)
- Switch - Liftgate - Interior (Remove and Replace)
- Handle - Interior Release - Door - Front - LH (Remove and Replace)
- Handle - Exterior Release - Door - Front - LH (Remove and Replace)
- Handle - Exterior Release - Door - Rear - LH (Remove and Replace)
- Bezel - Exterior Door Handle - Front - LH (Remove and Replace)
- Bezel - Exterior Door Handle - Rear - LH (Remove and Replace)
- Door Glass - LH - Front - Adjust
- Door Glass - LH - Front (Remove and Replace)
- Door Glass - LH - Rear - Adjust
- Door Glass - LH - Rear (Remove and Replace)
- Door Glass - Rear - Upper - LH (Remove and Replace)
- Door Glass - LH - Rear - Carrier
- Channel - Glass Run - Front - LH (Retrofit)
- Window Motor/Regulator Assembly - Front - LH (Remove and Replace)
- Window Regulator - Front - LH - Recalibrate
- Window Motor/Regulator Assembly - Rear - LH (Remove and Replace)
- Window Regulator - Rear - LH - Recalibrate
- Fixed Glass - Front Door - LH (Remove and Replace)
- Switch - Window Lift - Front Passenger's (Remove and Replace)
- Switch - Window Lift - Rear - LH (Remove and Replace)
- Closeout Panel - Door - Front - LH (Remove and Install)
- Closeout Panel - Door - Rear - LH (Remove and Install)
- Seal - Body - Side - Rear - Secondary - LH (Remove and Replace)
- Seal - Primary - Front Door - LH (Remove and Replace)
- Seal - Primary - Rear Door - LH (Remove and Replace)
- Seal - Door - Front - A Pillar - Margin - LH (Remove and Replace)
- Seal - Door- Front - Rocker - LH (Remove and Replace)
- Seal - Door - Front - LH (Remove and Replace)
- Seal - Door - Rear - C Pillar - Margin - LH (Remove and Replace)
- Seal - Rear Door - LH (Remove and Replace)
- Seal - Liftgate (Remove and Replace)
- Seal - Door Front Outer Belt - LH (Remove and Replace)
- Seal - Door Front Inner Belt - LH (Remove and Replace)
- Seal - Belt - Door Inner - Rear - LH (Remove and Replace)
- Seal - Door Rear Outer Belt - LH (Remove and Replace)
- Seal - Door - Rear - Upper - LH (Remove and Replace)
12 EXTERIOR FITTINGS
- Wheel Arch Liner - Front - LH (Remove and Replace)
- Wheel Arch Liner - Rear - LH (Remove and Replace)
- Panel - Aero Shield - Front (Remove and Replace)
- Panel - Aero Shield - Mid (Remove and Replace)
- Diffuser Panel - Rear (Remove and Replace)
- Nose Badge - Front (Remove and Replace)
- Rear Lettering (Remove and Replace)
- Applique - Liftgate (Remove and Replace)
- Badge - Ludicrous Speed (Retrofit)
- Bracket - License Plate - Front (Retrofit)
- Door Mirror Assembly - LH (Remove and Replace)
- Glass - Door Mirror - LH (Remove and Replace)
- Brightwork - Upper - Front - LH (Remove and Replace)
- Brightwork - Upper - Rear - LH (Remove and Replace)
- Applique - B-Pillar - LH (Remove and Replace)
- Applique - C-Pillar - LH (Remove and Replace)
- Applique - Rear Door - Front - LH (Remove and Replace)
- Brightwork - Body side - LH (Remove and Replace)
- Molding - Rocker Panel - LH (Remove and Replace)
- Carrier - Rocker Panel - LH (Remove and Replace)
- Pad - Lifting - Each (Remove and Replace)
- Garnish - Fender - Front - LH (Remove and Replace)
- Garnish - Fender - Rear - LH (Remove and Replace)
- Cladding - Door - Front - LH (Remove and Replace)
- Cladding - Door - Rear - LH (Remove and Replace)
- Cladding - Door - Rear - Wheel Arch - LH (Remove and Replace)
- Applique - Front Quarter - LH (Remove and Replace)
- Applique - Roof - Front (Remove and Replace)
- Applique - Roof - Rear (Remove and Replace)
- Active Spoiler Assembly (Remove and Install)
- Active Spoiler (Remove and Replace)
- Motor - Active Spoiler (Remove and Replace)
- Stanchion - Active Spoiler - LH (Remove and Replace)
- Applique - Active Spoiler (Remove and Replace)
- Torque Rod - Active Spoiler - LH (Remove and Replace)
- Hinge - Active Spoiler - LH (Remove and Replace)
- Panel - Cowl Screen (Remove and Replace)
- Assembly - Underhood Apron - Front (Remove and Replace)
- Underhood Apron - Center - Rear (Remove and Replace)
- Underhood Apron - LH (Remove and Replace)
- Trim - Liftgate Trough - LH (Remove and Replace)
- Trim - Liftgate Trough - Lower (Remove and Replace)
- Trim - Liftgate Trough - Upper (Remove and Replace)
- Trailer Hitch (Remove and Replace)
13 SEATS
- Riser - Driver's Seat - Outer (Remove and Replace)
- Riser - Front Seats - Inner (Remove and Replace)
- Motor - Headrest - Driver's (Remove and Replace)
- Motor - Seat Track - 2nd Row - LH (Remove and Replace)
- Track - Outer - 2nd Row Seat - LH (Remove and Replace)
- Track - Inner - 2nd Row Seat - LH (Remove and Replace)
- Seat Assembly - Driver's (Remove and Install)
- Cover - Seat Back - Driver's (Remove and Replace)
- Trim - Headrest - Driver's (Remove and Replace)
- Seat Assembly - Driver's (Remove and Replace)
- Seat Assembly - Passenger's (Remove and Replace)
- Seat Assembly - 2nd Row - LH (Remove and Install)
- Seat Assembly - 2nd Row - LH (With Broken Seat Track Motor) (Remove and Install)
- Seat Assembly - 2nd Row - LH (Remove and Replace)
- Seat Assembly - 2nd Row - Center (Remove and Replace)
- Module - 2nd Row Seat - LH (Remove and Replace)
- Latch Actuator - 2nd Row Seat - LH (Remove and Replace)
- Seat Assembly - 2nd Row - LH (Remove and Replace)
- Seat Assembly - 3rd Row (Remove and Replace)
- Cover - Seat Back - 2nd Row - LH (Remove and Replace)
14 INSTRUMENT PANELS
- Glove Box (Remove and Replace)
- IP Carrier (Remove and Replace)
- Cross Car Beam (Remove and Replace)
- Assembly - Frame - Instrument Cluster (Remove and Replace)
- Trim - Touch Screen Surround (Remove and Replace)
- Face Level Vent - Driver's - Outer (Remove and Replace)
- Face Level Vent - Driver's - Inner (Remove and Replace)
- Face Level Vent - Front Passenger's - Outer (Remove and Replace)
- Face Level Vent - Front Passenger's - Inner (Remove and Replace)
- Assembly - Bin - Storage Center Compartment (Remove and Replace)
- Assembly - Instrument Panel Lower - RH (Remove and Replace)
- Assembly - Instrument Panel Side Cover - LH (Remove and Replace)
- Assembly - Finisher - Instrument Panel - LH (Remove and Replace)
- Assembly - Finisher - Instrument Panel - RH (Remove and Replace)
- Assembly - Finisher - Instrument Panel - RH (Remove and Install)
- Assembly - Mesh Grille - Defrost (Remove and Replace)
- Assembly - Top Pad - Instrument Panel (Remove and Install)
- Assembly - Top Pad - Instrument Panel (Remove and Replace)
- Trim - Dash - Driver's Side - Lower (Remove and Replace)
- Trim - Dash - Driver's Side - Inner to Bezel (Remove and Replace)
- Assembly - Cover - Footwell - LH (Remove and Replace)
- Assembly - Cover - Footwell - RH (Remove and Replace)
15 INTERIOR TRIM
- Rear View Mirror (Remove and Replace)
- Sun Visor - Driver's (Remove and Replace)
- Trim - Liftgate - Upper (Remove and Replace)
- Trim - Liftgate - Middle (Remove and Replace)
- Trim - Liftgate - Lower (Remove and Replace)
- Trim - Liftgate - Side - LH (Remove and Replace)
- Grille - Speaker - Liftgate (Remove and Replace)
- Panel - Door Trim - Front - LH (Remove and Install)
- Panel - Door Trim - Front - LH (Remove and Replace)
- Panel - Door Trim - LH - Rear (Remove and Install)
- Panel - Door Trim - LH - Rear (Remove and Replace)
- Panel - Door Trim - LH - Rear - Upper (Remove and Replace)
- Garnish - Door Trim - LH - Rear - Lower (Remove and Replace)
- Gap Hider - Door Trim - LH - Rear - Mid (Remove and Replace)
- Rear -Upper Outer - Door Trim - LH - Rear (Remove and Replace)
- Grille - Speaker - Rear - LH (Remove and Replace)
- Bracket - Rear Door Trim - Center - LH (Remove and Replace)
- Bracket - Rear Door Trim - Upper - Rear - LH (Remove and Replace)
- Bracket - Rear Door Trim - Upper - Front - LH (Remove and Replace)
- Footrest - Driver's (Remove and Replace)
- Trim - Sill Panel - Front - LH (Remove and Replace)
- Trim - Sill Panel - Rear - LH (Remove and Replace)
- Welcome Plate - LH (Remove and Replace)
- Trim - A-Pillar - Upper - LH (Remove and Install)
- Trim - A-Pillar - Upper - LH (Remove and Replace)
- Trim - A-Pillar - Sun Visor Bezel - LH (Remove and Replace)
- Magnet - A-Pillar - Sun Visor Bezel - LH (Remove and Replace)
- Trim - A-Pillar - Lower - LH (Remove and Replace)
- Trim - B-Pillar - Upper - LH (Remove and Replace)
- Trim - B-Pillar - Lower - LH (Remove and Replace)
- Trim - C-Pillar - Lower - LH (Remove and Replace)
- Trim - C-Pillar - Mid - LH (Remove and Replace)
- Trim - C-Pillar - Upper - LH (Remove and Replace)
- Support - Parcel Shelf - LH (Remove and Replace)
- Racetrack Trim - Front - LH (Remove and Replace)
- Racetrack Trim - Lower - LH (Remove and Replace)
- Racetrack Trim - Rear - LH (Remove and Replace)
- Racetrack Trim - Upper - LH (Remove and Replace)
- Center Console Assembly (Remove and Install)
- Air Outlet - Center Console (Remove and Replace)
- Closeout Extension - Center Console - LH (Remove and Replace)
- Trim - Center Console - Side - LH (Remove and Replace)
- Trim - Center Console - Front (Remove and Replace)
- Trim - Center Console - Rear (Remove and Replace)
- Base - Armrest - Center Console (Remove and Install)
- Base - Armrest - Center Console (Remove and Replace)
- Armrest Pads - Center Console - 1st Row (Remove and Replace)
- Trim - Armrest - Center Console (Remove and Replace)
- USB Hub - Center Console (Remove and Replace)
- Headliner (Remove and Replace)
- Underhood Storage Unit (Remove and Replace)
- Lamp - Underhood Storage Area - LH (Remove and Replace)
- Trim - Rear Trunk - Sill (Remove and Replace)
- Trim and Carpet - Rear Trunk - Side - LH (Remove and Replace)
- Trim - Rear Trunk - Side - LH (Remove and Replace)
- Carpet - Trunk Floor (Remove and Replace)
- Trim - Rear Trunk - Rear Wall (Remove and Replace)
- Carpet - Underhood Storage (Remove and Install)
- Carpet - Interior Complete (Remove and Replace)
- Floor Panel - 2nd Row - Front (Remove and Replace)
- Floor Panel - 2nd Row - Middle (Remove and Replace)
- Carpet Assembly - Sliding - LH (Remove and Replace)
- Floor Panel - 2nd Row - Rear (Remove and Replace)
16 BATTERY SYSTEM
- HV Battery Assembly (Remove and Install)
- HV Battery Assembly (Remove and Replace)
- Ski - Side Rail - HV Battery - LH (Remove and Replace)
- HV Battery Blanket (Remove and Replace)
- HV Battery Coolant - Drain and Refill
17 ELECTRICAL
- Vehicle Electrical Isolation Procedure
- Disconnect 12V Power
- Battery - Auxiliary - 12V (Remove and Replace)
- Cage - Battery - Auxiliary - 12V (Remove and Replace)
- Fuse Box - Underhood (Remove and Replace)
- Fuse Box - Cabin - Front (Remove and Replace)
- Module - Front Body Controller - BCM (Remove and Replace)
- Module - Rear Body Controller - BCM (Remove and Replace)
- Module - Central Body Controller - BCM (Remove and Replace)
- Module - Autopilot - ECU (Remove and Replace)
- Module - HomeLink Transmitter (Remove and Replace)
- ECU Box (Remove and Install)
- Sensor - Radar - Center - Front (Remove and Replace)
- Calibration - Front Radar Sensor
- Camera - Forward Facing (Remove and Replace)
- Drive Cycle Calibration - Forward Facing Camera
- Target Calibration - Forward Facing Camera
- Camera - Rear View (Remove and Replace)
- Sensor - Parking Distance - Front - Each (Remove and Replace)
- Sensor - Parking Distance - Rear - Each (Remove and Replace)
- Module - Park Assist (Remove and Replace)
- Receiver - Remote Keyless Entry (RKE) - Immobilizer (Remove and Replace)
- Transmitter - Remote Keyless Entry (RKE) - Programming
- Antenna - Passive Entry - Front (Remove and Replace)
- Antenna - Passive Entry - Rocker - LH (Remove and Replace)
- Antenna - Passive Entry - Center Console (Remove and Replace)
- Antenna - Passive Entry - Rear (Remove and Replace)
- Antenna - Bluetooth Low Energy (BLE) (Remove and Replace)
- Siren - Battery Backed (Remove and Replace)
- Switch - Glove Box (Remove and Replace)
- Switch - Window Lift - Driver's (Remove and Replace)
- Switches - Steering Wheel (Remove and Replace)
- Welcome Lamp - Rear Door - LH (Remove and Replace)
- Headlight - Adjust - North America
- Headlight Assembly - LH (Remove and Replace)
- Tail Light Assembly - LH (Remove and Install)
- Tail Light Assembly - LH (Remove and Replace)
- Tail Light Assembly - RH (Remove and Replace)
- Lamp - Brake - High Mounted (Remove and Replace)
- Light - License Plate (Remove and Replace)
- Light - Fog/Reverse - Rear - LH (Remove and Replace)
- Lamp - Side Repeater - Front - LH (Remove and Replace)
- Lamp - Reflex - Rear - LH (Remove and Replace)
- Lamps - Fog - Front - Adjust
- Lamp - Fog - Front - LH (Remove and Replace)
- Switch - Hazard Warning (Remove and Replace)
- Bracket - Headlamp Support - LH (Remove and Replace)
- Bracket - Headlamp - Inner - LH (Remove and Replace)
- Bracket - Headlamp - Outer - LH (Remove and Replace)
- Horn - High Tone (Remove and Replace)
- Horn - Low Tone (Remove and Replace)
- Wiper Motor Assembly (Remove and Replace)
- Pump - Windshield Washer Reservoir (Remove and Replace)
- Reservoir - Windshield Washer (Remove and Replace)
- Sensor - Level - Windshield Washer Reservoir (Remove and Replace)
- Wiper Blades - Pair (Remove and Replace)
- Wiper Arms - Pair (Remove and Replace)
- Wiper Blades - Adjust
- Accelerator Assembly (Remove and Replace)
- Pyrotechnic Fuse (Remove and Replace)
18 THERMAL MANAGEMENT
- Filter - Cabin (Remove and Replace)
- Housing - Filter - HEPA (Remove and Replace)
- Duct - HEPA Filter (Remove and Replace)
- HVAC Assembly - Front (Remove and Replace)
- HVAC Assembly - Rear (Remove and Replace)
- Actuator - Inlet (Remove and Replace)
- Actuator - Driver's Temperature (Remove and Replace)
- Actuator - Mode (Remove and Replace)
- Actuator - Front Passenger's Temperature (Remove and Replace)
- Actuator - Defrost (Remove and Replace)
- Motor - Fan Assembly - Front HVAC (Remove and Replace)
- Motor - Fan Assembly - Rear HVAC (Remove and Replace)
- Hose - Drain - Front HVAC (Remove and Replace)
- Hose - Drain - Rear HVAC (Remove and Replace)
- Heater - Front PTC (Remove and Replace)
- Heater - Rear PTC (Remove and Replace)
- Module - Thermal Controller (Remove and Replace)
- Module - HVAC Controller - RCCM (Remove and Replace)
- Sensor - Air Quality (Remove and Replace)
- Sensor - Ambient Air Temperature (Remove and Replace)
- A/C Refrigerant Recovery and Recharge (Remove and Replace)
- A/C Refrigerant Leak Detection
- Condenser (Remove and Replace)
- Fan - Condenser (Remove and Replace)
- Receiver Dryer and Desiccant (Remove and Replace)
- Compressor (Remove and Replace)
- Mounting - Air Conditioning Compressor (Remove and Replace)
- Pipes - High/Low Pressure - Condenser to Chiller (Remove and Replace)
- Cooling Fan Module (Remove and Install)
- Pipes - High/Low Pressure - Charge Port (Remove and Replace)
- Pipe - High Pressure - Compressor to Condenser (Remove and Replace)
- Pipes - High/Low Pressure - Charge Port to Rocker (Remove and Replace)
- Pipes - High/Low Pressure - Rocker (Remove and Replace)
- Pipes - High/Low Pressure - Rocker to Rear HVAC (Remove and Replace)
- TXV Valve - Evaporator - Front (Remove and Replace)
- TXV Valve - Evaporator - Rear (Remove and Replace)
- Pressure Transducer - High Pressure (Remove and Replace)
- Pressure Transducer - Low Pressure (Remove and Replace)
- EXV Valve (Remove and Replace)
- Battery Chiller (Remove and Replace)
- Cooling System - Partial Refill and Bleed
- Cooling System - Drain and Refill
- Coolant System - Check and Fill
- Cooling System - Vacuum Refill
- Radiator (Remove and Replace)
- Reservoir Assembly - Coolant (Remove and Replace)
- 3 Way Coolant Valve - Radiator Bypass (Remove and Replace)
- 4 Way Coolant Valve - Series/Parallel (Remove and Replace)
- Coolant Heater - Electric - Battery (Remove and Replace)
- Battery Coolant Pump 1 (Remove and Replace)
- Battery Coolant Pump 2 (Remove and Replace)
- Powertrain Coolant Pump 1 (Remove and Replace)
- Powertrain Coolant Pump 2 (Remove and Replace)
- Active Louver - Center (Remove and Replace)
- HVAC Nose Duct (Remove and Replace)
20 SAFETY AND RESTRAINT
- Air bag - Driver's (Remove and Replace)
- Knee Air Bag - Driver's (Remove and Replace)
- Air bag - Front Passenger's (Remove and Replace)
- Knee Air Bag - Front Passenger's (Remove and Replace)
- Curtain Air Bag - Driver's (Remove and Replace)
- Curtain Air Bag - 2nd Row - LH (Remove and Replace)
- Module - Passive Safety Restraint - PSRCM (Remove and Replace)
- Seat Belt Assembly - 1st Row - LH (Remove and Replace)
- Buckle Assembly - 1st Row - LH (Remove and Replace)
- Seat Belt Assembly - 2nd Row - LH (Remove and Replace)
- Buckle Assembly - 2nd Row - LH (Remove and Replace)
- Seat Belt Assembly - 2nd Row - Center (Remove and Replace)
- Buckle Assembly - 2nd Row - Center (Remove and Replace)
- Buckle Assembly - 3rd Row - LH (Remove and Replace)
- Seat Belt Assembly - 3rd Row - LH (Remove and Replace)
- Pre-Tensioner - Outboard Lap - 1st Row - LH (Remove and Replace)
- Sensor - Airbag - Door - Front (Remove and Replace)
- Sensor - Intrusion - Door - Front (Remove and Replace)
- Sensor - Impact - Front (Remove and Replace)
- Sensor - Impact - B Pillar (Remove and Replace)
- Sensor - Impact - C Pillar (Remove and Replace)
- Sensor - Impact - D Pillar (Remove and Replace)
- Sensor - Occupant Classification - Front Passenger’s Seat - Calibration
21 INFOTAINMENT
- Instrument Cluster (Remove and Replace)
- Media Control Unit - Touch Screen (Remove and Replace)
- Media Control Unit - Touch Screen (Remove and Install)
- SD Card - Media Control Unit (Remove and Replace)
- Speaker - Front Door (Remove and Replace)
- Tweeter - Rear Door - LH (Remove and Replace)
- Subwoofer Assembly (Remove and Replace)
- Tweeter - A Pillar - LH (Remove and Replace)
- Speaker - Rear Door - LH (Remove and Replace)
- Premium Boost Amplifier (Remove and Replace)
- Chime - Rear Door - LH (Remove and Replace)
- Chime - Liftgate (Remove and Replace)
- Speaker - Liftgate - LH (Remove and Replace)
- Tweeter - Liftgate - LH (Remove and Replace)
- Speaker - Dash - LH (Premium Only) (Remove and Replace)
- Speaker - Dash - Center (Remove and Replace)
- Tweeter - Dash (Remove and Replace)
- Tuner - AM - FM (Remove and Replace)
- Microphone - LH (Remove and Replace)
- Dock Connector - Telephone - USB - Center Console (Remove and Replace)
- Antenna - AM/FM/RKE (Remove and Replace)
- Antenna - FM2 and Defrost Grid (Remove and Replace)
- Antenna - RF Filter - LH (Remove and Replace)
- Antenna Amplifier - AM/FM and RKE (Remove and Replace)
- Antenna Amplifier - FM2 (Remove and Replace)
- Antenna - Satellite Radio (Remove and Replace)
- Antenna - GPS (Remove and Replace)
- Antenna - WiFi (Remove and Replace)
- Antenna - GSM - LH (Remove and Replace)
30 CHASSIS
- Subframe Assembly - Rear (Remove and Install)
- Subframe Assembly - Rear (Remove and Replace)
- Subframe Assembly - Front (Remove and Install)
- Subframe Assembly - Front (Remove and Replace)
- Skidplate - Front (Remove and Replace)
- Skidplate - Rear (Remove and Replace)
- Skid Bar - Front Subframe (Remove and Replace)
- Bash Plate - Front - Extrusion (Remove and Replace)
31 SUSPENSION
- Four Wheel Alignment Check
- Four Wheel Alignment - Check and Adjust
- Ride Height - Adjust
- Suspension - Front - Check Torque
- Knuckle - Suspension - Front - LH (Remove and Replace)
- Hub - Front - LH (Remove and Replace)
- Link - Sway Bar - Front - LH (Remove and Replace)
- Sway Bar - Front (Remove and Replace)
- Control Arm - Upper - Front - LH (Remove and Replace)
- Control Arm - Upper - Front - RH (Remove and Replace)
- Link - Lower - Fore - LH (Remove and Replace)
- Link - Lower - Aft - LH (Remove and Replace)
- Suspension - Rear - Check Torque
- Hub - Rear - LH (Remove and Replace)
- Control Arm Assembly - Rear - Lower - LH (Remove and Replace)
- Link - Suspension - Rear - Upper - LH (Remove and Replace)
- Toe Link Assembly - Rear - LH (Remove and Replace)
- Sway Bar - Rear (Remove and Replace)
- Drop Link - Sway Bar - Rear - LH (Remove and Replace)
- Integral Link - Rear - LH (Remove and Replace)
- Knuckle - Suspension - Rear - LH (Remove and Replace)
- Air Spring Module - Front - LH (Remove and Replace)
- Air Spring Module - Front - RH (Remove and Replace)
- Air Spring Module - Rear - LH (Remove and Replace)
- Air Spring Module - Rear - RH (Remove and Replace)
- Air Suspension - Pressurize/Depressurize - One Air Spring
- Air Suspension - Depressurize - Full System
- Air Suspension - Pressurize - Full System
- Compressor - Air Suspension (Remove and Replace)
- Valve Block - Air Suspension (Remove and Replace)
- Reservoir - Air Suspension (Remove and Replace)
- Sensor - Ride Height - Front - LH (Remove and Replace)
- Sensor - Ride Height - Rear - LH (Remove and Replace)
- Air Suspension Lines - Front (Remove and Replace)
- Air Suspension Lines - Rear (Remove and Replace)
- Air Line - Air Suspension - Reservoir to Compressor (Remove and Replace)
- Air Line - Air Suspension - Compressor to Valve Block (Remove and Replace)
- Air Line - Air Suspension - Valve Block Exhaust (Remove and Replace)
- Module - Air Suspension - ECU (Remove and Replace)
- Spring and Damper Assembly - Front - LH (Remove and Replace)
- Spring and Damper Assembly - Rear - LH (Remove and Replace)
32 STEERING
- Steering Rack (Remove and Replace)
- Tie Rod End - LH (Remove and Replace)
- Seal - Steering Rack (Remove and Replace)
- Shaft - Steering Column - Intermediate Lower (Remove and Replace)
- Shaft - Steering Column - Intermediate Upper (Remove and Replace)
- Clockspring - Steering Column (Remove and Replace)
- Steering Wheel (Remove and Replace)
- Steering Column (Remove and Replace)
- Module - Steering Column Control (Remove and Replace)
33 BRAKES
- Brake Rotor - Front - LH (Remove and Replace)
- Brake Rotor - Rear - LH (Remove and Replace)
- Brake Caliper - Front - LH (Remove and Replace)
- Brake Caliper - Rear - LH (Remove and Replace)
- Brake Pads - Front - Set (Remove and Replace)
- Brake Pads - Rear - Set (Remove and Replace)
- Brake Pads - Burnishing
- Shield - Dust - Brake - Front - LH (Remove and Replace)
- Shield - Dust - Brake - Rear - LH (Remove and Replace)
- Brake Hose - Flexible - Front - LH (Remove and Replace)
- Brake Hose - Flexible - Rear - LH (Remove and Replace)
- Bleed Procedure - One Caliper (Remove and Replace)
- Bleed Procedure - System (Remove and Replace)
- Brake Lines - Master Cylinder to ABS (Remove and Replace)
- Rear Park Brake Caliper Release
- Park Brake Caliper - Release - Harness Tool - Through Calipers
- Park Brake Caliper - Release - Harness Tool - Through ECU
- Brake Caliper - Rear - Park Brake - LH (Remove and Replace)
- Brake Pads - Park Brake - Set (Remove and Replace)
- Brake Pads - Park Brake - Burnishing
- Module - Electric Park Brake - EPB (Remove and Replace)
- ABS Modulator Assembly (Remove and Replace)
- Sensor - Wheel Speed - ABS - Front - LH (Remove and Replace)
- Sensor - Wheel Speed - ABS - Rear - LH (Remove and Replace)
- Brake Sensor Cluster - ESC (Remove and Replace)
- Electromechanical Brake Booster Assembly (Remove and Replace)
- Switch - Brake Light (Remove and Replace)
- Brake Pedal (Remove and Replace)
34 WHEELS AND TIRES
- Wheel (Remove and Install)
- Wheels - Axle Set (Remove and Install)
- Wheels - Vehicle - Set (Remove and Install)
- Tire - Front - LH
- Tire - Front - LH - Rebalance
- Tire - Front - LH - Repair
- Tire Rotation
- Wheel Sensor - TPMS (Remove and Replace)
- TPMS Sensor - ID Learn Procedure
- Module - TPMS (Remove and Replace)
39 FRONT DRIVE UNIT
- Front Drive Unit (Remove and Install)
- Front Drive Unit (Remove and Replace)
- Mount - Front Drive Unit - RH (Remove and Replace)
- Mount - Front Drive Unit - LH (Remove and Replace)
- Mount - Front Drive Unit - LH (Adjust)
- Front Gearbox Fluid (Remove and Replace)
- Front Oil Seal - Differential to Halfshaft Assembly - LH (Remove and Replace)
- Front Oil Seal - Differential to Halfshaft Assembly - RH (Remove and Replace)
- Front Halfshaft Assembly - LH (Remove and Replace)
- Front Halfshaft Assembly - RH (Remove and Replace)
- Jackshaft Assembly - Front (Remove and Replace)
40 REAR DRIVE UNIT
- Drive Unit - Rear - Large (Remove and Install)
- Drive Unit - Rear - Large (Remove and Replace)
- Drive Unit - Rear - Small (Remove and Install)
- Drive Unit - Rear - Small (Remove and Replace)
- Mount - Motor - Side (Remove and Replace)
- Sensor - Motor - Speed (Remove and Replace)
- Rear Gearbox Fluid - Small Drive Unit (Remove and Replace)
- Rear Gearbox Fluid - Large Drive Unit (Remove and Replace)
- Rear Oil Seal - Differential to Halfshaft Assembly - Small Drive Unit - LH (Remove and Replace)
- Rear Oil Seal - Differential to Halfshaft Assembly - Large Drive Unit - LH (Remove and Replace)
- Rear Halfshaft Assembly - Small Drive Unit - LH (Remove and Replace)
- Rear Halfshaft Assembly - Large Drive Unit - LH (Remove and Replace)
44 HIGH VOLTAGE SYSTEM
- Charge Port (Remove and Replace)
- Charge Port - Manual Release of Cable
- Door - Charge Port (Remove and Replace)
- Charger (Remove and Replace)
- DCDC Converter (Remove and Replace)
- Coolant Heater - Electric - Battery (Remove and Replace)
- Forward Junction Box (Remove and Replace)
- HV Rapid Splitter Vehicle Side (Remove and Replace)
- HV Harness - Charger to Charge Port (Remove and Replace)
- HV Harness - Charger to Rear PTC Heater (Remove and Replace)
- HV Harness - FJB to Front Drive Unit (Remove and Replace)
- HV Harness - Rapid Splitter to FJB (Remove and Replace)
50 EXTERNAL CHARGING CONNECTORS
- Handle and Cable Assembly - 40A Wall Connector (Remove and Replace)
- Handle and Cable Assembly - 80A Wall Connector (Remove and Replace)
- 200A Fuses - Wall Connector (Remove and Replace)
- Firmware Update - CHAdeMO Charging Adapter
Cover - Seat Back - 2nd Row - LH (Remove and Replace)

... BACK